PowerPC 440GP Embedded Processor Data Sheet
Features
• PowerPC
440 processor core operating up to
500MHz with 32KB I- and D-caches
• On-chip 8 KB SRAM
• Selectable processor:bus clock ratios of 3:1,
4:1, 5:1, 5:2, 7:2
• Double Data Rate (DDR) Synchronous DRAM
(SDRAM) 32/64-bit interface operating up to
133MHz
• External Peripheral Bus for up to eight devices
with external mastering
• DMA support for external peripherals, internal
UART and memory
• PCI-X V1.0a interface (32 or 64 bits, up to
133MHz) with support for conventional PCI
V2.2
• Programmable Interrupt Controller supports
interrupts from a variety of sources.
• Programmable General Purpose Timers (GPT)
• Two serial ports (16750 compatible UART)
• Two IIC interfaces
• General Purpose I/O (GPIO) interface available
• JTAG interface for board level testing
• Internal Processor Local Bus (PLB) runs at
DDR SDRAM interface frequency
• PowerPC processor boot from PCI memory
• Two Ethernet 10/100Mbps half- or full-duplex
interfaces. Operational modes supported are
MII, RMII, and SMII.
Description
Designed specifically to address high-end
embedded applications, the PowerPC 440GP
(PPC440GP) provides a high-performance, low
power solution that interfaces to a wide range of
peripherals by incorporating on-chip power
management features and lower power dissipation.
This chip contains a high-performance RISC
processor core, DDR SDRAM controller,8KB
SRAM, PCI-X bus interface, Ethernet interfaces,
control for external ROM and peripherals, DMA with
scatter-gather support, serial ports, IIC interface,
and general purpose I/O.
Technology: IBM CMOS SA-27E, 0.18
µ
m
(0.11 L
eff
), 5-layer metal
Package: 25mm, 552-ball Ceramic Ball Grid Array
(CBGA)
Power (estimated): Less than 4.0W. Less than
1.0 W in sleep mode
Supply voltages required: 3.3V, 2.5V, 1.8V
4/1/03
Page 1 of 64
PowerPC 440GP Embedded Processor Data Sheet
Contents
Ordering and PVR Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Address Maps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
PowerPC 440 Processor Core . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Internal Buses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
PCI-X Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
DDR SDRAM Memory Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
On-Chip SRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
External Peripheral Bus Controller (EBC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Ethernet Controller Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
DMA Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Serial Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
IIC Bus Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
General Purpose Timers (GPT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
General Purpose IO (GPIO) Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Universal Interrupt Controller (UIC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
JTAG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Signal Lists . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Signal Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Heat Sink Mounting Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
Test Conditions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Spread Spectrum Clocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
DDR SDRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Initialization . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Strapping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
EEPROM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Figures
PPC440GP Functional Block Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
25mm, 552-Ball CBGA Package . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Heat Sink Attached With Spring Clip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
Heat Sink Attached With Adhesive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
Timing Waveform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
Input Setup and Hold Waveform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Output Delay and Float Timing Waveform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
DDR SDRAM Write Cycle Timing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
DDR SDRAM Read Cycle Timing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Page 2 of 64
4/1/03
PowerPC 440GP Embedded Processor Data Sheet
Tables
System Memory Address Map . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
DCR Address Map . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Signals Listed Alphabetically . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Signals Listed by Ball Assignment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Pin Summary . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Signal Functional Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Absolute Maximum Ratings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Package Thermal Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Recommended DC Operating Conditions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Input Capacitance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
DC Power Supply Loads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Clocking Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
Peripheral Interface Clock Timings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
I/O Specifications—All Speeds . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
I/O Specifications—400, 466, and 500MHz . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Strapping Pin Assignments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
4/1/03
Page 3 of 64
PowerPC 440GP Embedded Processor Data Sheet
Ordering and PVR Information
For information on the availability of the following parts, contact your local IBM sales office.
Product
Name
PPC440GP
PPC440GP
PPC440GP
PPC440GP
PPC440GP
PPC440GP
PPC440GP
PPC440GP
Notes:
Order Part Number
1
IBM25PPC440GP-3CC400C
IBM25PPC440GP-3CC400CZ
IBM25PPC440GP-3CC400E
IBM25PPC440GP-3CC400EZ
IBM25PPC440GP-3CC466C
IBM25PPC440GP-3CC466CZ
IBM25PPC440GP-3CC500C
IBM25PPC440GP-3CC500CZ
Processor
Frequency
400MHz
400MHz
400MHz
400MHz
466MHz
466MHz
500MHz
500MHz
Package
25mm, 552 CBGA
25mm, 552 CBGA
25mm, 552 CBGA
25mm, 552 CBGA
25mm, 552 CBGA
25mm, 552 CBGA
25mm, 552 CBGA
25mm, 552 CBGA
Rev
Level
C
C
C
C
C
C
C
C
PVR Value
0x40120481
0x40120481
0x40120481
0x40120481
0x40120481
0x40120481
0x40120481
0x40120481
JTAG ID
0x02052049
0x02052049
0x02052049
0x02052049
0x02052049
0x02052049
0x02052049
0x02052049
1. Z at the end of the Order Part Number indicates a tape-and-reel shipping package. Otherwise, the chips are shipped in a tray.
Each part number contains a revision code. This is the die mask revision number and is included in the part
number for identification purposes only.
The PVR (Processor Version Register) is software accessible and contains additional information about the
revision level of the part. Refer to the
PPC440GP User’s Manual
for details on the register content.
Order Part Number Key
IBM25PPC440GP-3CC500Ex
Shipping Package:
Blank = Tray
Z
= Tape and reel
IBM Part Number
Case Temperature Range
C = -40°C to +85°C
E = -40°C to +105°C
Processor Speed
Revision Level
Grade 3 Reliability
Package (CBGA)
Page 4 of 64
4/1/03
PowerPC 440GP Embedded Processor Data Sheet
PPC440GP Functional Block Diagram
Universal
Interrupt
Controller
Clock
Control
Reset
Timers
MMU
PPC440
Processor Core
JTAG
32KB
D-Cache
Trace
32KB
I-Cache
Arb
On-chip Peripheral Bus (OPB)
GP
Timers
GPIO
IIC
x2
UART
x2
Power
Mgmt
DCRs
45 internal
13 external
DCR Bus
SRAM
8KB
DMA
Controller
(4-Channel)
OPB
Bridge
Processor Local Bus (PLB)
Ethernet
x2
External
External
Bus Master
Bus
Controller
Controller
66 MHz max
32-bit addr
32-bit data
MAL
DDR SDRAM
Controller
133MHz max
13-bit addr
32/64-bit data
PCI-X
Bridge
133 MHz max
1 MII
or
2 RMII
or
2 SMII
The PPC440GP is designed using the IBM Microelectronics Blue Logic
methodology in which major
functional blocks are integrated together to create an application-specific product (ASIC). This approach
provides a consistent way to create complex ASICs using IBM CoreConnect Bus
Architecture.
Note:
IBM CoreConnect buses provide:
• 128-bit PLB interfaces up to 133.33MHz, 2.1GB/s
• 32-bit OPB interfaces up to 66.66MHz, 266MB/s
Address Maps
The PPC440GP incorporates two address maps. The first is a fixed processor system memory address map.
This address map defines the possible contents of various address regions which the processor can access.
The second address map is for Device Configuration Registers (DCRs). The DCRs are accessed by software
running on the PPC440GP processor through the use of
mtdcr
and
mfdcr
instructions.
4/1/03
Page 5 of 64
工控电子
